fuel lines

Basically title, I have a 94, thats entirely original, ran good at the end of last summer, but I have the time so I'm going to change the hoses out and hope I get away from having to do a carb rebuild. My question is: is there any benefit to changing out the grey hoses that are the vent lines...

Hello everyone, I recently got a 99 GSX Limited 951. I need to replace all my oil lines (green sludge). What sizes do I need to do all of them? I was planning on just tracing them for the length but as far as diameter does anyone know what sizes I am going to need? To my understanding I would...

Hey everyone! So I have a 94 GTS and a GTX. I replaced the grey fuel lines, cleaned the carbs, made sure everything was tight and they won’t start. I don’t think it is the pump because the GTS was running before I did all of this but it was running rough at full speed and the GTX wouldn’t run...

Hey everyone, I have two identical 2002 Seadoo RX carbed skis and the past two seasons have had just the hardest time getting one of them started the first day of the year. This year it took around three hours of choking, cranking, engine kicks over, then dies, charge the battery, repeat. I...

With the help of this forum, I rebuilt the carbs (all OSD parts) on my 1994 & 1995 GTXs 2 yrs ago, and swapped all the gas lines out at that time; however, in a haste to get on the lake before the summer was over, I didn't swap out the fuel selectors (me = idiot). They both screamed down the...

Thought I had better start a new thread rather than clog up the meet and greet. A couple of minor issues with it which led me to this forum and has already given me some good pointers as to what to look at. She bogs down at around 40MPH, anything below that is fine and the acceleration is...

Hi all, new to forum yesterday and have reviewed hundreds and hundreds of posts looking for my answers. Here is what I bought: 1997 SPX that I believe to be an old racing machine (I can see the faded racing decals and performance parts decals on the sides and hood). It has the following...

Hey there forum members! I have searched high and low and cannot find what I am looking for. I have the service manual, but it is a bit unclear as to what I am needing. I have a red with purple 1998 GSX Limited with the 951cc motor. All stock, no mods. Here is the deal... Bought this ski, the...

Hi Everyone! New to forums, but thought I'd give this a try. I need help with my boat! I've owned boats for 34 years, but this is the first SeaDoo. The boat is great when it's running. I can give details to my question regarding lack of acceleration to plane out after I see if this...

I have two fuel lines coming from the baffle pickup assembly that uses a Y to go into one line then another Y to split off to each carb. I believe in less is more. Does anyone have any input on me just using two lines from the baffle pickup assy directly to the two carbs... one line for each...

Hi, Here's my story I have a 1996 gsx, had the famous clogged filters in carbs due to the grey fuel lines... I have now, changed all the fuel lines, cleaned fuel selector valve and both carbs, (weird thing I noticed the tinny filter in the rearmost carb was heavily clogged but the one from...

I just bought this machine yesterday. It was running great until my buddy flipped it over and the engine compartment filled with water. I replaced the battery. Here is the video I posted on youtube. https://www.youtube.com/watch?v=S1kfQirycI0 I was just wondering what other things I could...

I'm in the process of replacing the original gray Tempo fuel lines on my '97 GTX & XP and was planning on leaving the vent lines alone. Fortunately, I've replaced all of the lines between the tank and the carb and I haven't seen any green 'goo' on either ski. My question is, am I safe to...

Just got this PWC and knew I needed to invest a little time and work to get it going. First of all I knew the Tempo lines were trashed, so I took it to my small engine mechanic to replace them. He said these were ethanol rated and were better than the new ones I would get from AutoZone. He...

*Update - Disregard this post. I posted this question in the correct forum. *:cheers: Lots of great advice here! Just got this PWC and knew I needed to invest a little time and work to get it going. First of all I knew the Tempo lines were trashed, so I took it to my small engine mechanic to...

OK, I changed my fuel lines and pulled the tanks also to empty and clean out. I made a diagram of the lines to help me route the new fuel lines. I'm guessing my fuel line map and want to make sure the lines are being routed properly. In this pic, do I have the lines labeled correctly in...

1996 Seadoo xp surges/bogs at full throttle Had the carbs rebuilt last year ran perfect first time out full throttle and everything now runs fine until you pass the 45 MPH point then it starts to surge and bog it will go full throttle then back down then back up then back down etc. Just...

if anybody has pictures or something that could help

Hello, Just took the jet ski out after replacing the old fuel lines. I avoided rebuilding the carbs because the previous owner had not run it in a few years and I was hoping the gunk in the old fuel lines hadn't disrupted the fuel filters in the carbs. So, when I brought up to full throttle...

I had a problem with my 1996 xp (787). It hesitated when I accelerated, and would cut off if I didn't let off the throttle. Looking back, I think this original problem was the fuel filter in the carb. But, I rebuilt the fuel pump (including the carb filter), replaced the gray fuel lines, put...