97 Sportster electrical issue

[Toby1]

Just went out the other day. Came in without any issues. Havn't had one issue this year thsu far. I always start her up once before heading to the lauch site. (properly of course). Couple days ago acted like battery was dead, battery tested fine, boutght a new one anyway.
Starter begins to turn engine, but after about 3-5 revolutions stops turning. (as if battery was low). Checked fuses, one was bad, replaced. Tried again. Still same issue. In fuse box, a few wires are hot, (the small yellow ones, upper starboard side). Battery is full charge. Any help on this one will be appreciated.

-Toby

 

[Dr Honda]

Small yellow wires are hot?? Those are probably the rectifier/regulator wires. You may have a bad regulator. By any chance... was the bad fuse a 15a?

As far as the "Not cranking" thing... I'd say it's time for a starter. Sometimes you can just take it apart, and clean it... or replace the brushes.

 

[Toby1]

fuse

yes, the fuse was the 15a. As far as the starter, it turns over, but almost acts as if there isnt enough juice to turn it more than a couple revolutions. (how difficult is it to replace these two items?

 

[Dr Honda]

The regulator is easy. Depending on the type you have... it's a bolt or two, and a couple wires, or a single plug.

The stater is a bastard to get out. It's under the exhaust, and kind of under the the engine. You can do it... just take your time.

 

[Toby1]

Thanks

Awsome. Thanks for the help and confidence. I have printed schimatics for it and im pretty sure i can do it. Im going to start with the regulator/rectifier. by the sound, i think the starter isnt malfunctioning, but i will order one and change it. Hopefully i can play a little before i have to put it in. Either way, im going to get it done. Thank you again for your help. I will post when i get it done!

-Toby