2000 RX 951 DI fuel issue

[joe6905]

Hello everyone if this has been discussed before i apologize i haven't been able to find it.
I have a 2000 millennium 951 RX DI it starts up and runs great when you get down to half of a tank it falls on its face and keeps shutting off will bog down like its running out of fuel cuts in and out you have to limp it back to the dock. Fill it up and it runs great again tell half a tank again. its pretty much dead on 5 gallon trip put another 5 in again lol and your good to go again. any suggestion to what to look for. i havent tore it apart yet i am assuming theres a pin hole or something in the fuel line in the tank at this level. Not sure how the fuel pump system is set up in it yet tell i take it apart i just know I'm not giving 1,400 for a fuel pump assembly lol.
ANY AND ALL HELP WOULD BE GREATLY APPRECIETED.

 

[mikidymac]

The fuel pump is the the bottom of the tank so as long as there is fuel in the tank it shouldn't matter.
It could be that the check-valve for the tank vent isn't working and the tank is building a vacuum. I would check the check-valve and/or try opening the fuel cap when it gets down to the problem level and see if that makes a difference.

 

[etemplet]

Remove the fuel canister and replace both filters. Make sure everything is clean when you go back.

 

[joe6905]

i have new filters i was going to put on it while i had it apart do you think that could be the reason it only runs a half tank of fuel out

 

[etemplet]

All you can do is make it like it should be. Test the fuel pressure. Good Luck.