Recent content by SPrider13

  1. S

    RESTO 94 sp blew up

    Took it out on the water today with a brand new carb gasket. Ski ran great for like 5 min and right as I had it almost dialed in perfect, it quit on me. Now, it idles perfect but when I go to punch the throttle it Boggs and sounds like a popping noise from inside the engine bay. If I very slowly...
  2. S

    RESTO 94 sp blew up

    Osd dosent sell a mikuni bn38 with choke. Pretty much no where does. I searched for a couple days and finally found a rebuilt carb off a 91 sp. I did swap the jets over so no problems should be there. I ordered a new carb base gasket off of osd so hopefully I’ll have a update when that comes in...
  3. S

    RESTO 94 sp blew up

    Thanks for the tip. Now I’ve got to find the air leak. Could it be the gasket where the carb bolts onto the Intake manifold? I know there’s supposed to be a gasket there. Only problem is that I can’t find a 38mm mikuni carb gasket anywhere. So currently using the beat up seal that was there in...
  4. S

    1994 SP Throttle Handle/Cable

    Where the choke and throttle cables bolt onto the air intake is wheee you can adjust the tension. If it’s so loose that there’s no tension, your spring for the throttle return may be shot. This is completely due to assembly, not oil pressure. Mess around with the tensioner ( the part that bolts...
  5. S

    RESTO 94 sp blew up

    Also would like to note that the carb I swapped it out with and am currently using is from a 91 sp. however, I swapped the jets from the 94 carb to the 91 carb so it is not basically the same carb
  6. S

    RESTO 94 sp blew up

    From what I’ve read about engines running with out spark plugs like diesel ones is that it’s from their high compression and lean mixture which makes no sense because my low speed was one and a half turns out, more rich than factory.
  7. S

    RESTO 94 sp blew up

    Ok so I did this and got it started. Ran okay so I hooked it up to the water and let it idle for a couple min. The to try and just clear the fuel I Reved it a couple times to about half throttle. When I let off the throttle after the second rev however, the engine held the rpms and started to...
  8. S

    RESTO 94 sp blew up

    Factory is low-1 high-0. Does that mean the high should be all the way in? Confused on this.
  9. S

    RESTO 94 sp blew up

    Lines were swapped. Started up and ran OK this morning. Tried tuning high and low speeds to the best of my ability and out of water. Weirdly tho when I punched the throttle it and let off the engine continued to run at high rpm for a couple seconds even after I hit the kill switch and then when...
  10. S

    RESTO 94 sp blew up

    I also re did the fuel lines. The line that goes from the external fuel filter should go to the top nipple of the carb and the return line should go on the bottom correct? May have had these switched.
  11. S

    RESTO 94 sp blew up

    Finally got a carb off a old 91 sp. I know the jets r different from the 94 so I swapped the jets from the broken carb to the one I got. Put it all back together and fuel lines are in correct spots. Go to start it and it just keeps cranking. The carb I got is in pristine condition and was just...
  12. S

    RESTO 94 sp blew up

    From what I’ve seen online it looks like the 34mm mikuni? What exactly do the number of mm relate to
  13. S

    RESTO 94 sp blew up

    The original is black and the one from osd is silver. Everything looks the same except there’s an extra flange and spring assembly on the old one. I looked to see if if I could switch over the parts but there’s no pre drilled slots to do so. Can’t seem to find one with the second flange and that...
  14. S

    RESTO 94 sp blew up

    In addition, anyone know the part number for the carb, can’t find it anywhere. Don’t wana order anything that won’t work.
Back
Top