Recent content by Scooter610

  1. Scooter610

    Fuel Diagram 240 efi

    Perfect, thank you!!! I suppose its time to get the manual, appreciate the share.
  2. Scooter610

    Fuel Diagram 240 efi

    In trying to sort out a possible fuel pressure issues, does anyone have a fuel flow diagram from the tank, to the lift pump, in/out of the pressure pump, etc. etc. etc.... and finally back to the tank? At first glance it doesn't seem logical the ins and outs of the fuel system. Any help would...
  3. Scooter610

    2000 Islandia, how to test fuel pressure regultor

    Thanks, I am definitely getting pressure out of the pump. I hooked my gauge directly to the outlet of the vst pump and got 85 psi. 0 psi past the regulator or at the schrader valve. I see they are pricey, $350 I did find a reference that 805227A1 mounts the same but supplies 37 psi instead...
  4. Scooter610

    2000 Islandia, how to test fuel pressure regultor

    Thank you, I did take it apart and check the screen which was clear. I'm wondering I'd hooking up a vacuum tester will do anything to control pressure while testing. I assume it should be at 35ish when key on not running, or trying to start.
  5. Scooter610

    2000 Islandia, how to test fuel pressure regultor

    My islandia has no fuel pressure at the Schrader valve. I have pressure out of the vst high pressure pump, but not past the regulator. Is there a way to test the regulator? Engine won't run and this seemed to happen all of a sudden. It should hold 35ish psi when not running, correct?
  6. Scooter610

    2000 islandia hasn't been started in 8 years...

    Amazing! Tell me where the dang drain plug is for the drive when you find it please!
  7. Scooter610

    Gear/stator oil change

    Where is the drive oil drain plug on a 2000 Islandia?
  8. Scooter610

    Impros stator impeller repair

    I agree with the comments about Glen, he is top notch. He has been reworking my Wetbike impellers for many many years. Call Us +(951) 737-2900 Fax +(951) 737-2900 impros@impros.com
  9. Scooter610

    Islandia Steering Cable nut size?

    22 mm was correct. New below and snug as a bug thank you.
  10. Scooter610

    Islandia Steering Cable nut size?

    My steering cable nuts are loose, which needs a crow foot wrench. I can't tell what size it is. Any one know so I can get it tightened up? Also, the rubber shaft boots are cracked, are they replaceable? Thanks!
  11. Scooter610

    2000 Islandia center storage won't drain

    This is a pic of my center storage, it usually holds 3 in of water or more. There is a large drain hole to the back but not going down through the bottom and I see no hole there.
  12. Scooter610

    2000 Islandia center storage won't drain

    Thanks Dr. There is a big hole in the back and looks like it goes toward the engine bay. I dont think there is any mods at all to this boat. Has a blue carpet in the locker. So drill down, or to the back? Fyi, new plugs and runs like a champ. 38 to 40 on GPS at 6k even.
  13. Scooter610

    2000 Islandia center storage won't drain

    I can't seem to understand why my center storage ski locker compartment won't drain, there is a hole and its clear but I don't know where it goes. It doesn't get any lower when on plane either. Any help is appreciated.
  14. Scooter610

    2000 Islandia, questions about plugs, oil, and steering

    That's where I found a comment on the bushing, there was another site that said about the same but I cant find it again.
  15. Scooter610

    2000 Islandia, questions about plugs, oil, and steering

    Mercury Oiling Gear Failure - The Hull Truth - Boating and Fishing Forum
Back
Top